Empire P)-1 Owner's Manual Page 1

Page 1INSTALLATION INSTRUCTIONSANDOWNER’S MANUALLOFT FIREPLACE INSERTDIRECT VENT GAS FIREPLACE HEATERMODEL SERIESDVL25IN33(N,P)-1DVL33IN33(N,P)-1DVL25

29209-0-0911Page 10VENTING AND INSTALLATION1. To begin, remove the glass door from the unit. Note: The glass door assembly is secured to the r

29209-0-0911 Page 11VENTING AND INSTALLATIONVentSystemApprovalsFigure 8 shows the vent termination caps and systems approved for use with these mode

29209-0-0911Page 12Figure 8VENTING AND INSTALLATIONBLOWER ACCESSCOVER PLATEBLOWERPOWER CORDOPTIONAL ON/OFFSWITCH LOCATIONVENT CLAMPSRECTANGULARTERMINA

29209-0-0911 Page 13VerticalThroughtheRoofApplicationsThe Gas Fireplace Insert has been approved for:a) Vertical installations up to 35 feet

29209-0-0911Page 14ALTERNATEON/OFFSWITCHINSTALLATIONWIRING THE FIREPLACENOTICE: Electrical wiring must be installed by a licensedelectrici

29209-0-0911 Page 15SURROUND PANEL INSTALLATIONINSTALLING THE TRIM SURROUNDSCombustible materials MUST NEVER overlap onto the front face. WARNINGWHEN

29209-0-0911Page 16BLOWER ACCESSORY INFORMATIONThe appliance, when installed must be electrically con-nectedandgroundedinaccordancewithlo

29209-0-0911 Page 17OPTIONAL DECORATIVE GLASS PLACEMENTWARNING: Failuretopositionthepartsinaccordancewiththediagramsandinstructionsbelow

29209-0-0911Page 18MILLIVOLT OPERATING INSTRUCTIONSThe OWNER should carefully read and follow these operating instructions at all times. Lower the doo

29209-0-0911 Page 19TO TURN OFF GAS TO FIREPLACE1. Stop! Read the safety information above.2. Set REMOTE/OFF/ON switch to OFF.3. Turn off all elec

29209-0-0911Page 2TABLE OF CONTENTSImportant Safety Information ...

29209-0-0911Page 20OptionalWallSwitchPosition the wall switch in the desired position on a wall. Run a maximum of 25 feet (7.8m) or less length of 1

29209-0-0911 Page 21Withproperinstallationandmaintenance,yournewDirectVentGasFireplacewillprovideyearsoftrouble-freeservice.Ifyoudo

29209-0-0911Page 22IPI ELECTRONIC SYSTEM OPERATING INSTRUCTIONSAttention:  For shipping purposes, the Electronic ControlModule and Receiver

29209-0-0911 Page 23IPI ELECTRONIC SYSTEM WIRING DIAGRAMIf any of the original wire as supplied with this unit must be replaced, it must be replaced w

29209-0-0911Page 24TO TURN OFF GAS TO FIREPLACE1. STOP! Read the safety information above.2. Turn OFF electric power to the appliance.3. Remove fro

29209-0-0911 Page 25INTERMITTENT CONTROL SYSTEM TROUBLESHOOTINGBriefDescriptionoftheComponentsThe gas valve is tted with a manual HI/LO knob to a

29209-0-0911Page 26INTERMITTENT CONTROL SYSTEM TROUBLESHOOTING1If the DFC giving signal lock out:The board should be unlocked toreinitiate a pilot fla

29209-0-0911 Page 27INTERMITTENT CONTROL SYSTEM TROUBLESHOOTING2Main burner lightswhen the pilot onlyshould light.Pilot holds the flame?.Main burner i

29209-0-0911Page 28INSERT MAINTENANCE AND SERVICEAlthough the frequency of servicing and maintenance will depend on use and the type of installa

29209-0-0911 Page 29ACCESSORIESThe following accessory parts can be obtained from your Empire Comfort Systems dealer. If you need additional informati

29209-0-0911 Page 3DO NOT OPERATE THIS APPLIANCE WITHOUT GLASS FRONT PANEL INSTALLEDBeforeenclosingtheventpipeassembly,operatetheapplianceto

29209-0-0911Page 30INSERT PARTS VIEW12345877910111213141516171819202122232225242644272830383563733323429314136394041434245464744INSERT PARTS LISTINDEX

29209-0-0911 Page 31INSERT PARTS LIST USE ONLY MANUFACTURER’S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.11 27731 27856 277

29209-0-0911Page 32To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.com. To provide

29209-0-0911 Page 33APPLIANCE SERVICE HISTORYDate DealerName ServiceTechnicianName ServicePerformed/Notes

29209-0-0911Page 34APPLIANCE SERVICE HISTORYDate DealerName ServiceTechnicianName ServicePerformed/Notes

29209-0-0911 Page 35APPLIANCE SERVICE HISTORYDate DealerName ServiceTechnicianName ServicePerformed/Notes

29209-0-0911Page 36EMPIREEMPIREComfort SystemsEmpire Comfort Systems Inc.918 Freeburg Ave. Belleville, IL 62220If you have a general question about o

29209-0-0911Page 4Somepeoplecannotsmellwell.Somepeoplecannotsmelltheodorofthechemicalputintothegas.Youmustndoutifyoucansmell

29209-0-0911 Page 5InstructionstoInstaller1. Leave instruction manual with owner after installation.2. Have owner ll out and mail registration ca

29209-0-0911Page 6SPECIFICATIONSDVL25IN(3,7)3L MODELS LP NatInput Btu/hr Maximum 20,000 20,000 Btu/hr Minimum 16,000 14,000KWH (Maximum)

29209-0-0911 Page 7FIREPLACE INSERT DIMENSIONS3 3/4”3”3”K2 3/8”LIGFJ6”INTAKE3” DIA.FLUE3” DIA.BANEDMF1 5/8”HC2 3/8”OFigure 1When planning a replace i

29209-0-0911Page 8MANTLE AND TRIM CLEARANCESCOMBUSTIBLEMANTEL/TRIM AREAZYXWVUTSRQPOB12”TOPOF INSERTDEFGHIJKLCMNSURROUND PANELSACombustibleMaterialNo

29209-0-0911 Page 9Figure 5The gas pipeline can be brought in through the right or left side of the appliance. The insert has a Flexline with shutoff