Page 1INSTALLATION INSTRUCTIONSANDOWNER’S MANUALEMPIREEMPIREComfort SystemsDIRECT VENTGAS FIREPLACE HEATERMODELSDV25IN33L(N,P)-3DV25IN73L(N,P)-1DV(33,
32227-0-0513Page 10VENTING AND INSTALLATION1. Beforebeginning,removeglassdoorandlog packagefromunit.Alsochecktomakesurethereisnohid
32227-0-0513 Page 11VENTING AND INSTALLATIONVent System ApprovalsFigure 8 shows the vent termination caps and systems approved for use with these mode
32227-0-0513Page 12Figure 8VENTING AND INSTALLATION
32227-0-0513 Page 13VERTICAL TERMINATIONDetermining Minimum Vent Height Above the Roof. WARNINGMajor U.S. building codes specify minimum chimney and/o
32227-0-0513Page 14ALTERNATE ON/OFF SWITCH INSTALLATIONWIRING THE FIREPLACENOTICE: Electrical wiring must be installed by a licensed electrician. CAUT
32227-0-0513 Page 15SURROUND PANEL INSTALLATIONINSTALLING THE TRIM SURROUNDSCombustible materials MUST NEVER overlap onto the front face. WARNINGWHEN
32227-0-0513Page 16BLOWER ACCESSORY INFORMATIONThe appliance, when installed must be electrically connect-ed and grounded in accordance with local cod
32227-0-0513 Page 17LOG PLACEMENTBefore you begin:This replace insert is supplied with a set ofsevenceramicberlogs.Donothandlethe
32227-0-0513Page 18OPERATING INSTRUCTIONSThe OWNER should carefully read and follow these operating instructions at all times. Lower the door assembly
32227-0-0513 Page 191. Stop! Read the safety information above.2. Set REMOTE/OFF/ON switch to OFF.3. Turnoffallelectricpowertotheappliance
32227-0-0513Page 2TABLE OF CONTENTSImportant Safety Information ...
32227-0-0513Page 20STANDING PILOT WIRINGSTANDING PILOT WIRING DIAGRAMFigure 22For Standing Pilot Ignition WiringAppliance Requirements WARNINGDO NOT C
32227-0-0513 Page 21With proper installation and maintenance, your new Direct Vent Gas Fireplace will provide years of trouble-free
32227-0-0513Page 22Figure 23IPI ELECTRONIC SYSTEM OPERATING INSTRUCTIONS5.25 VDC ELECTRONIC CONTROL VALVEThe electronic control valve system includes
32227-0-0513 Page 23IPI ELECTRONIC SYSTEM WIRING DIAGRAMIf any of the original wire as supplied with this unit must be replaced,itmustbereplacedw
32227-0-0513Page 241. Set REMOTE/OFF/ON switch to OFF.2. Turn off all electric power to the appliance if service is to be performed(ifapplicable
32227-0-0513 Page 25Brief Description of the ComponentsThegasvalveisttedwithamanualHI/LOknobtoallowforman-ual modulation of the gas outl
32227-0-0513Page 26INTERMITTENT CONTROL SYSTEM TROUBLESHOOTING
32227-0-0513 Page 27INTERMITTENT CONTROL SYSTEM TROUBLESHOOTING
32227-0-0513Page 28INSERT MAINTENANCE AND SERVICEAlthoughthefrequencyofservicingandmaintenancewilldependon use and the type of installa
32227-0-0513 Page 29DECORATIVE ACCESSORIESThe following accessory parts can be obtained from your Empire Comfort Systems dealer. If you need additiona
32227-0-0513 Page 3DO NOT OPERATE THIS APPLIANCE WITHOUT GLASS FRONT PANEL INSTALLEDBefore enclosing the vent pipe assembly, operate the appliance to
32227-0-0513Page 30DECORATIVE ACCESSORIESDecorative FrontsStyle Model Number Style Model NumberTribeccaDVD(25,33,35)C(BL,HP,SS)• Black• Hammered Pew
32227-0-0513 Page 31INSERT PARTS VIEW143435363738394041424447461110578323332467454312319171918222331212420132627302928153016251248495150535455525657
32227-0-0513Page 32INSERT PARTS LIST USE ONLY MANUFACTURER’S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.INDEX NO.PART NUMBE
32227-0-0513 Page 3330 16223 16223 16223 16223 16223 16223 SPRING RETAINER ASSEMBLY31 - - 25548 25548 25548 25548 FLAME SHIELD, LEFT32 M163 M163 M163
32227-0-0513Page 34To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.com. To provide
32227-0-0513 Page 35Empire Comfort Systems Inc. warranties this hearth product to be free from defects at the time of purchase and for the periods spe
32227-0-0513Page 36EMPIREEMPIREComfort SystemsEmpire Comfort Systems Inc.918 Freeburg Ave. Belleville, IL 62220Ifyouhaveageneralquestionabouto
32227-0-0513Page 4SAFETY INFORMATION FOR USERS OF LP-GASand explosions. In its natural state,
32227-0-0513 Page 5Instructions to Installer1. Installer must leave instruction manual with owner after installation.2. Installermusthaveownerll
32227-0-0513Page 6SPECIFICATIONSSurround DescriptionS253BLContemporaryBlackSurroundforDV25IN,6x3 inchS333BLContemporaryBlackSurroundforD
32227-0-0513 Page 7FIREPLACE INSERT DIMENSIONSFigure 1Whenplanningareplaceinsertinstallation,it’snecessarytodetermine:• Theventsystemcon
32227-0-0513Page 8MANTLE AND TRIM CLEARANCESFigure 3Distance from Face of FireplaceHeight Above Top of InsertA 10” N 23”B 9-1/4” O 22”C 8-3/4” P 21”D
32227-0-0513 Page 9GAS SUPPLYThe gas pipeline can be brought in through the right or left side of the appliance. The insert has a Flexline with shutof
Comments to this Manuals