Page 1INSTALLATION INSTRUCTIONSANDOWNER’S MANUALINNSBROOK FIREPLACE INSERTDIRECT VENT GAS FIREPLACE HEATERMODEL SERIESDV25IN33L(N,P)-1DV33IN33L(N,P)-1
23015-6-0408Page 10VENTING AND INSTALLATION1. Before beginning, remove glass door and log package from unit. Also check to make sure there is no hidd
23015-6-0408 Page 11VENTING AND INSTALLATIONVent System ApprovalsFigure 8 shows the vent termination caps and systems approved for use with these
23015-6-0408Page 12Figure 8VENTING AND INSTALLATIONRECTANGULARTERMINATION CAP(DVVK3FV KIT)VENT CLAMPSINTAKE VENTFLUE EXHAUST VENTOPTIONAL ON/OFFSWITCH
23015-6-0408 Page 13Vertical Through the Roof ApplicationsThe Gas Fireplace Insert has been approved for:a) Vertical installations up to 35 feet in h
23015-6-0408Page 14ALTERNATE ON/OFF SWITCH INSTALLATIONWIRING THE FIREPLACENote: Electrical wiring must be installed by a licensed electrician.CAUTION
23015-6-0408 Page 15SURROUND PANEL INSTALLATIONINSTALLING THE TRIM SURROUNDSCombustible materials MUST NEVER overlap onto the front face.WARNIN
23015-6-0408Page 16BLOWER ACCESSORY INFORMATIONThe appliance, when installed must be electrically connected and grounded in accordance with loc
23015-6-0408 Page 17LOG PLACEMENTBACKLOGLEFTTWIGRIGHTTWIGRIGHTCENTERLOGRIGHT FRONTLOGLEFT FRONTLOGLEFTCENTERLOGFigure 18Figure 19Note: Center the fron
23015-6-0408Page 18OPERATING INSTRUCTIONSInitial LightingUpon completing the gas line or turning the gas valve on after it has been in the “OFF” posit
23015-6-0408 Page 191. Stop! Read the safety information above.2. Set REMOTE/OFF/ON switch to OFF.3. Turn off all electric power to the appliance (
23015-6-0408Page 2TABLE OF CONTENTSImportant Safety Information ...
23015-6-0408Page 20STANDING PILOT WIRINGSTANDING PILOT WIRING DIAGRAMFor Standing Pilot Ignition WiringAppliance RequirementsWARNING: DO NOT CONNECT 1
23015-6-0408 Page 21With proper installation and maintenance, your new Direct Vent Gas Fireplace will provide years of trouble-free service. If you do
23015-6-0408Page 22INSERT MAINTENANCE AND SERVICEAlthough the frequency of servicing and maintenance will depend on use and the type of installation,
23015-6-0408 Page 23Decorative Mission LouverDecorative Leaf LouverDecorative Arch LouverSTD Louvers 45 DegSTD Contemporary SurroundCast Iron Traditio
23015-6-0408Page 24INSERT PARTS VIEW123456789101113141516171920212223242526272829303133343536373839404171232424318444546484749
23015-6-0408 Page 25INSERT PARTS LIST PART NUMBER INDEX NO. DV25IN33L(N,P) DV33IN33L(N,P) DV35IN33L(N,P) DESCRIPTION 1 22950 22950 22950 GUI
23015-6-0408Page 26Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts
23015-6-0408 Page 27SERVICE NOTES
23015-6-0408Page 28EMPIREEMPIREComfort SystemsEmpire Comfort Systems Inc.918 Freeburg Ave. Belleville, IL 62220If you have a general question about o
23015-6-0408 Page 3DO NOT OPERATE THIS APPLIANCE WITHOUT GLASS FRONT PANEL INSTALLEDBefore enclosing the vent pipe assembly, operate the appliance to
23015-6-0408Page 4Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. You must find out if you can smell
23015-6-0408 Page 5Warning: ANY CHANGE TO THIS FIREPLACE OR ITS CONTROLS CAN BE DANGEROUS.Improper installation or use of the fireplace can cau
23015-6-0408Page 6SPECIFICATIONSDV25IN33L MODELS LP NatInput Btu/hr Maximum 25,000 25,000 Btu/hr Minimum 17,000 17,000KWH (Maximum) 7.30 7.30
23015-6-0408 Page 7FIREPLACE INSERT DIMENSIONSFigure 1When planning a fireplace insert installation, it’s necessary to determine:• The vent system con
23015-6-0408Page 8MANTLE AND TRIM CLEARANCESCOMBUSTIBLEMANTEL/TRIMAREA12”10”1 3/4”23”11”Combustible MaterialNo greeting cards, stockings or ornamentat
23015-6-0408 Page 9Figure 5The gas pipeline can be brought in through the right or left side of the appliance. The insert has a Flexline with shutoff
Comments to this Manuals